Freeze-thaw pretreatment of poplar sapwood dust.

The paper is focused on the effect of freezing and cyclic freezing-thawing pretreatment of poplar sapwood (Populus alba L.). The experimental comparison was carried out by the sawdust fraction 0.7 mm as (a) water-saturated and (b) dry. Monosaccharide yields, as well as an amount of acetic acid, were measured after 6, 24, 48, 72, and 96 hours of enzymatic hydrolysis with 15% load of the enzyme measured to total cellulose content. The influence of freezing rate on total yields was observed on equally prepared samples with different weights (31 g, 25 g, 62.5 g, 125 g, 250 g, 500 g, and 1000 g) by "cubic" tests. To increase the efficiency of pretreatment, a cyclic freezing-thawing experiment at temperatures -20°C and +25°C was performed. The results show that single freezing of grounded poplar sapwood impregnated by water or dry in its matter is not a sufficient pretreatment method, so cyclic freeze-thaw is needed to enhance the yield of monosaccharides. Analysis of cubic test showed that slower freezing process has a positive effect on enzyme accessibility.