Reduction of Heavy Hydrocarbons from Oilfield Produced Water

This paper presents attempts to reduce the concentration of organic pollutants in oilfield produced wastewater before its discharge into natural water bodies or reinjection into the wells. The contaminant content was significantly decreased by wastewater treatment, based on solid phase adsorption, photocatalytic degradation of organic molecules and chemical oxidation of oily compounds. The study was conducted with real wastewater, which is in practice released in the environment. The produced water samples, taken from four sampling points in the oilfield site, were analyzed for physicochemical (temperature, redox potential (Eh), conductivity, pH, dissolved oxygen) and specific (chemical oxygen demand (COD), total oily hydrocarbons (TOH), phenols) parameters, cations (Ca2+, Mg2+, Na+, K+) and anions (Cl−, HCO3−, SO42−, S2−), in order to determine the initial water status. The organic contaminants in oilfield produced water showed COD of 39–58 mg/L, TOH of 152–363 mg/L and phenols of 0.07–0.21 mg/L. The TOH was chosen as a suitable parameter for the evaluation of the treatment method efficiency. The adsorption on activated charcoal decreased the TOH levels up to 52 mg/L, which corresponds to 85% removal of oily compounds. Chemical oxidation, carried out with Ca(ClO)2 in a concentration of 400 mg/L for 1 h at room temperature, showed TOH removal in the range of 80–94% for different wastewater samples. The use of 300 mg/L TiO2 or ZnO under UV irradiation for 12 h led to TOH removal of 25–78% and 82–92%, respectively. Both photocatalysts were characterized by using X-ray diffraction, reflectance UV-vis spectroscopy and scanning electron microscopy. The crystal forms anatase and wurtzite for TiO2 and ZnO, respectively, were found. The estimated band gap of 3.48 eV for direct transition in TiO2 and 3.25 eV for ZnO agrees well with that reported in the literature. Higher photodegradation of organic compounds was observed for ZnO, indicating that it absorbed more light photons than TiO2 did. A mechanism for photocatalytic degradation over a more efficient photocatalyst, ZnO, was proposed based on the GC-MS analysis of raw water and treated effluents produced for 6 and 12 h.