Optimization, characterization and biosafety of carotenoids produced from whey using Micrococcus luteus.

This study aimed to optimize the production of carotenoid pigments from Micrococcus luteus (ATCC 9341) through the statistical screening of media components and the characterization of antimicrobial, antioxidant, cytogenetic and cytotoxic activities. A BOX-Behnken design was used to assess the effects of whey concentration, inoculum size, pH, temperature, and agitation speed on carotenoid yield. The optimum combination increased production to 2.19 g/L, with a productivity of 0.045 g L^-1 h^-1 and a productivity yield of 0.644 g/g, as confirmed by an observed carotene production of 2.19 g/L. The final response surface model fitting the data had an R² of 0.9461. High-performance liquid chromatography (HPLC) analysis identified 12 carotenoid pigment compounds produced by M. luteus. The extracts displayed moderate antimicrobial efficacy against Gram-positive bacteria such as Bacillus cereus (ATCC 11778), Staphylococcus aureus (ATCC 6538), and E. faecalis (ATCC 19433), with inhibition zone diameters (IZD) of 29.0, 14.0, and 37.0 mm, respectively, at 1000 μg/mL. However, its effectiveness against Gram-negative bacteria is limited. In comparison, tetracycline exhibited greater antimicrobial potency. The IC₅₀ value of carotenoids was used to indicate the antioxidant activity. IC₅₀ value from the DPPH assay was 152.80 mg/100mL. An IC₅₀ cytotoxicity value greater than 300 μg/mL was found against normal mouse liver cells, with over 68% cell viability even at 300 μg/mL, indicating low toxicity. Histological structure studies revealed normal myocardial muscle tissue, lung tissue, and kidney tissue sections, whereas liver tissue sections revealed ballooning degeneration of hepatocytes and disorganization of hepatic cords. Cytogenetic parameters revealed that the carotene treatment group had a mitotic index (70%) lower than that of the control but higher than that of the positive control, mitomycin, and did not substantially increase numerical (1.2%) or structural aberrations compared with those of the control, suggesting a lack of genotoxic effects under the experimental conditions. In conclusion, optimized culture conditions enhanced carotenoid yields from M. luteus, and the extracts displayed promising bioactivity as moderate antibiotics against certain gram-positive bacteria and as antioxidants. The high IC₅₀ values demonstrate biosafety. Overall, this bioprocess for enhanced carotenoid production coupled with bioactivity profiling and low cytotoxicity support the application of M. luteus carotenoids.