Pub Date : 2024-01-16DOI: 10.47370/2072-0920-2023-19-4-205-211
A. I. Belyaev, N. Y. Petrov, G. N. Zvereva, E. A. Kuznetsova
The experiment showed that in the risky farming zone where the experiment was carried out, the introduction of mineral nutrition into southern chernozem significantly influenced the content of nutrients in the soil. Experimental studies were carried out in 2018-2021 on the southern chernozem of the Volgograd region, on the fields of the «Eliseev A.N.» peasant farm, located in the Mikhailovsky district. The varieties of spring durum wheat Donskaya Elegiya, Krasnokutka 13 and winter durum wheat Aksinit and Agat Donskoy were compared with the addition of the calculated amount of mineral nutrition for given yield levels. The experience showed that in variants without the addition of mineral nutrition, it accumulated in the early spring (this was the maximum accumulation) from 5.02 (Don Elegy) to 5.07 (Aksinit) mg per 100 g of soil. The application of N147P5K90 to all varieties was marked by the maximum accumulation of the amount of nitrate nitrogen, and it varied between varieties from 7.01 (Aksinit variety) to 7.57 (Krasnokutka 13 variety) mg per 100 g of soil. By the end of the growing season the least amount of nitrate nitrogen was retained on the Aksinit variety – 4.11 mg per 100 g of soil. While the Krasnokutka 13 variety retained the level of 4.71 mg per 100 g of soil. A similar dependence was observed for the accumulation and consumption of mobile phosphorus. As a result, in varieties without the use of mineral nutrition, the yield ranged from 1.34 t/ha (Krasnokutka 13) to 3.41 t/ha (Aksinit). The maximum yield values were obtained from the application of N74Р27К45 and it ranged from 2.41 t/ha (variety Krasnokutka 13) to 4.02 t/ha (variety Aksinit).
{"title":"Ways to increase durum wheat yield in the south of Russia","authors":"A. I. Belyaev, N. Y. Petrov, G. N. Zvereva, E. A. Kuznetsova","doi":"10.47370/2072-0920-2023-19-4-205-211","DOIUrl":"https://doi.org/10.47370/2072-0920-2023-19-4-205-211","url":null,"abstract":"The experiment showed that in the risky farming zone where the experiment was carried out, the introduction of mineral nutrition into southern chernozem significantly influenced the content of nutrients in the soil. Experimental studies were carried out in 2018-2021 on the southern chernozem of the Volgograd region, on the fields of the «Eliseev A.N.» peasant farm, located in the Mikhailovsky district. The varieties of spring durum wheat Donskaya Elegiya, Krasnokutka 13 and winter durum wheat Aksinit and Agat Donskoy were compared with the addition of the calculated amount of mineral nutrition for given yield levels. The experience showed that in variants without the addition of mineral nutrition, it accumulated in the early spring (this was the maximum accumulation) from 5.02 (Don Elegy) to 5.07 (Aksinit) mg per 100 g of soil. The application of N147P5K90 to all varieties was marked by the maximum accumulation of the amount of nitrate nitrogen, and it varied between varieties from 7.01 (Aksinit variety) to 7.57 (Krasnokutka 13 variety) mg per 100 g of soil. By the end of the growing season the least amount of nitrate nitrogen was retained on the Aksinit variety – 4.11 mg per 100 g of soil. While the Krasnokutka 13 variety retained the level of 4.71 mg per 100 g of soil. A similar dependence was observed for the accumulation and consumption of mobile phosphorus. As a result, in varieties without the use of mineral nutrition, the yield ranged from 1.34 t/ha (Krasnokutka 13) to 3.41 t/ha (Aksinit). The maximum yield values were obtained from the application of N74Р27К45 and it ranged from 2.41 t/ha (variety Krasnokutka 13) to 4.02 t/ha (variety Aksinit).","PeriodicalId":516588,"journal":{"name":"New Technologies","volume":null,"pages":null},"PeriodicalIF":0.0,"publicationDate":"2024-01-16","publicationTypes":"Journal Article","fieldsOfStudy":null,"isOpenAccess":false,"openAccessPdf":"","citationCount":null,"resultStr":null,"platform":"Semanticscholar","paperid":"140505649","PeriodicalName":null,"FirstCategoryId":null,"ListUrlMain":null,"RegionNum":0,"RegionCategory":"","ArticlePicture":[],"TitleCN":null,"AbstractTextCN":null,"PMCID":"","EPubDate":null,"PubModel":null,"JCR":null,"JCRName":null,"Score":null,"Total":0}
Pub Date : 2024-01-16DOI: 10.47370/2072-0920-2023-19-4-197-204
S. Basiev, E. A. Tsagareva, G. T. Gazzaev, Z. A. Tsarikaev
The article highlights issues of breeding work at Gorsk State Agrarian University in 2022. Obtaining productive potato varieties that resistant to various pathogens in the conditions of the mountain foothills of the North Caucasus is the goal of the research. The main objectives are to identify dominant characteristics of the studied varieties for their further use as parent forms, to evaluate hybrid offspring based on the main economically valuable characteristics, to select the most valuable genotypes according to variety models for a given region (6). In the collection nursery parental pairs were identified for further use in the breeding process. The studies were carried out on mountain meadow and leached chernozems of the North Ossetia-Alania. The experiments were carried out according to the methods of selection and seed production developed by VIR, VIZR and VNIKH named after. A.G. Lorja. In various nurseries of the breeding process promising hybrid offspring were identified. In the maternal nursery more than 6.5 thousand seeds were obtained as a result of backcrossings in 7 combinations. In the nursery of first-year seedlings 15% of genotypes were rejected according to morphological characteristics. During harvesting 42% of genotypes were rejected and the selection rate was 58%. In the nursery of second-year seedlings the average selection among planted genotypes averaged 79.2%. In the nursery of seedlings of the third year hybrids of four combinations were tested, 3 of which were rejected, only 133 combinations of offspring were obtained, and the selection rate was 11.1%. The isolated hybrid progenies, namely, 12.64/368, 12.40/1 and 12.64/394 with a yield of 51.7 t/ha, 48.7 t/ha and 48.1 t/ha, and marketability of 82.3%, 80.0% and 84 .0% will accordingly be transferred to a breeding nursery for further research and submission to the State Crop Testing Site of the Russian Federation.
{"title":"Potato breeding at Gorsk State Agrarian University","authors":"S. Basiev, E. A. Tsagareva, G. T. Gazzaev, Z. A. Tsarikaev","doi":"10.47370/2072-0920-2023-19-4-197-204","DOIUrl":"https://doi.org/10.47370/2072-0920-2023-19-4-197-204","url":null,"abstract":"The article highlights issues of breeding work at Gorsk State Agrarian University in 2022. Obtaining productive potato varieties that resistant to various pathogens in the conditions of the mountain foothills of the North Caucasus is the goal of the research. The main objectives are to identify dominant characteristics of the studied varieties for their further use as parent forms, to evaluate hybrid offspring based on the main economically valuable characteristics, to select the most valuable genotypes according to variety models for a given region (6). In the collection nursery parental pairs were identified for further use in the breeding process. The studies were carried out on mountain meadow and leached chernozems of the North Ossetia-Alania. The experiments were carried out according to the methods of selection and seed production developed by VIR, VIZR and VNIKH named after. A.G. Lorja. In various nurseries of the breeding process promising hybrid offspring were identified. In the maternal nursery more than 6.5 thousand seeds were obtained as a result of backcrossings in 7 combinations. In the nursery of first-year seedlings 15% of genotypes were rejected according to morphological characteristics. During harvesting 42% of genotypes were rejected and the selection rate was 58%. In the nursery of second-year seedlings the average selection among planted genotypes averaged 79.2%. In the nursery of seedlings of the third year hybrids of four combinations were tested, 3 of which were rejected, only 133 combinations of offspring were obtained, and the selection rate was 11.1%. The isolated hybrid progenies, namely, 12.64/368, 12.40/1 and 12.64/394 with a yield of 51.7 t/ha, 48.7 t/ha and 48.1 t/ha, and marketability of 82.3%, 80.0% and 84 .0% will accordingly be transferred to a breeding nursery for further research and submission to the State Crop Testing Site of the Russian Federation.","PeriodicalId":516588,"journal":{"name":"New Technologies","volume":null,"pages":null},"PeriodicalIF":0.0,"publicationDate":"2024-01-16","publicationTypes":"Journal Article","fieldsOfStudy":null,"isOpenAccess":false,"openAccessPdf":"","citationCount":null,"resultStr":null,"platform":"Semanticscholar","paperid":"140505953","PeriodicalName":null,"FirstCategoryId":null,"ListUrlMain":null,"RegionNum":0,"RegionCategory":"","ArticlePicture":[],"TitleCN":null,"AbstractTextCN":null,"PMCID":"","EPubDate":null,"PubModel":null,"JCR":null,"JCRName":null,"Score":null,"Total":0}
Pub Date : 2024-01-16DOI: 10.47370/2072-0920-2023-19-4-190-196
I. Bandurko, Z. S. Daguzhieva
The article describes the results of work on the creation of low-growing pear varieties with a red outer color of a fruit, adapted to the conditions of the foothill zone of the North-Western Caucasus (the Republic of Adygea). Many years of studying and selection pear variety were carried out by employees of the Maikop Experimental Station, a branch of VIR. The breeding task was to combine a number of valuable traits in the genotype of new varieties: small size of trees, early onset of fruiting, high yield, bright color of fruits, their good taste and late ripening, as well as resistance to fungal diseases. A comprehensive assessment of the source material was carried out and genotypes that were promising for breeding were identified. To obtain weak-growing hybrids, the weak-growing varieties of Obilnaya, Jacques Tellier, Triomphe de Vienne, Amiral Gervais, De ľAssomption and others were used. The variety of Max Red Bartlett (Max Red Bartlett, Williams Red) and its descendants became the donors of the red outer color of the fruit. To improve the quality of fruits and late ripening, high-quality varieties of Abbé Fetel, Doyenné d'Hiver, Martin and others were used. As a result of simple and multi-stage crossings, a hybrid fund of more than 100 samples was created, from which genotypes were isolated that had a complex of positive economically valuable traits that were promising for production and selection. Their brief characteristics are given.
文章介绍了根据西北高加索（阿迪盖亚共和国）山麓地区的条件培育果实外色为红色的低矮梨品种的工作成果。VIR 分支机构 Maikop 实验站的员工进行了多年的梨品种研究和选育工作。育种任务是在新品种的基因型中结合一系列有价值的性状：树体小、结果早、产量高、果实颜色鲜艳、口感好、成熟晚，以及对真菌疾病的抗性。对原始材料进行了全面评估，并确定了有希望育成的基因型。为了获得生长势弱的杂交种，使用了生长势弱的奥比尔纳亚、雅克-泰利埃、维埃纳凯旋、阿米尔-热尔韦、德阿索姆普里特等品种。Max Red Bartlett（Max Red Bartlett、Williams Red）及其后代成为果实外层红色的捐献者。为了提高果实质量和晚熟性，使用了 Abbé Fetel、Doyenné d'Hiver、Martin 等优质品种。通过简单和多阶段杂交，建立了一个由 100 多个样本组成的杂交基金，从中分离出了具有一系列积极经济价值性状的基因型，这些基因型有望用于生产和选育。现简要介绍其特征。
{"title":"The results of the implementation of the pear breeding program in the conditions of Adygea","authors":"I. Bandurko, Z. S. Daguzhieva","doi":"10.47370/2072-0920-2023-19-4-190-196","DOIUrl":"https://doi.org/10.47370/2072-0920-2023-19-4-190-196","url":null,"abstract":"The article describes the results of work on the creation of low-growing pear varieties with a red outer color of a fruit, adapted to the conditions of the foothill zone of the North-Western Caucasus (the Republic of Adygea). Many years of studying and selection pear variety were carried out by employees of the Maikop Experimental Station, a branch of VIR. The breeding task was to combine a number of valuable traits in the genotype of new varieties: small size of trees, early onset of fruiting, high yield, bright color of fruits, their good taste and late ripening, as well as resistance to fungal diseases. A comprehensive assessment of the source material was carried out and genotypes that were promising for breeding were identified. To obtain weak-growing hybrids, the weak-growing varieties of Obilnaya, Jacques Tellier, Triomphe de Vienne, Amiral Gervais, De ľAssomption and others were used. The variety of Max Red Bartlett (Max Red Bartlett, Williams Red) and its descendants became the donors of the red outer color of the fruit. To improve the quality of fruits and late ripening, high-quality varieties of Abbé Fetel, Doyenné d'Hiver, Martin and others were used. As a result of simple and multi-stage crossings, a hybrid fund of more than 100 samples was created, from which genotypes were isolated that had a complex of positive economically valuable traits that were promising for production and selection. Their brief characteristics are given.","PeriodicalId":516588,"journal":{"name":"New Technologies","volume":null,"pages":null},"PeriodicalIF":0.0,"publicationDate":"2024-01-16","publicationTypes":"Journal Article","fieldsOfStudy":null,"isOpenAccess":false,"openAccessPdf":"","citationCount":null,"resultStr":null,"platform":"Semanticscholar","paperid":"140506678","PeriodicalName":null,"FirstCategoryId":null,"ListUrlMain":null,"RegionNum":0,"RegionCategory":"","ArticlePicture":[],"TitleCN":null,"AbstractTextCN":null,"PMCID":"","EPubDate":null,"PubModel":null,"JCR":null,"JCRName":null,"Score":null,"Total":0}
Pub Date : 2024-01-16DOI: 10.47370/2072-0920-2023-19-4-183-189
O. V. Chugunova, P. Bikbulatov, A. S. Sokolov, N. V. Zavorokhina
The article presents the results of the influence of high hydrostatic pressure (HHP) on some functional properties of pea protein isolate. HHP was combined with different pH conditions to investigate the cumulative effect of HHP-based food processing conditions on the functional properties of pea protein isolate. Pea protein isolate solutions prepared at different pH conditions (5.0, 6.0, and 7.0) were subjected to HHP treatment at 200, 400, and 600 mPa at 18 °C for 5 min. The water resisting capacity (WRC), solubility and emulsifying properties of pea isolate samples were determined. It was found that treatment with NPP increased the VUS of pea protein isolates by 1.5 times. The greatest increase was observed in samples treated with a pressure of 400 mPa, at pH=7. An increase in solubility was found with an increase in pH from 6 to 7 when using a pressure of 400 and 600 mPa, however, for a sample of soybean isolate at pH 7 and a pressure of 200 mPa, on the contrary, a decrease in solubility was recorded. It has been shown that the effect of NPP on the emulsifying properties of pea protein depends on the processing conditions. In some cases, HPP can improve emulsifying properties, providing more stable emulsions. However, increasing exposure to high pressure up to 600 mPa leads to a decrease in emulsifying stability. The optimal parameters for using NPP for pea isolate proteins are a pH in the range of 6-7, and a pressure of 400 mPa.
{"title":"Investigation of the effect of high hydrostatic pressure on functional properties of pea protein isolate","authors":"O. V. Chugunova, P. Bikbulatov, A. S. Sokolov, N. V. Zavorokhina","doi":"10.47370/2072-0920-2023-19-4-183-189","DOIUrl":"https://doi.org/10.47370/2072-0920-2023-19-4-183-189","url":null,"abstract":"The article presents the results of the influence of high hydrostatic pressure (HHP) on some functional properties of pea protein isolate. HHP was combined with different pH conditions to investigate the cumulative effect of HHP-based food processing conditions on the functional properties of pea protein isolate. Pea protein isolate solutions prepared at different pH conditions (5.0, 6.0, and 7.0) were subjected to HHP treatment at 200, 400, and 600 mPa at 18 °C for 5 min. The water resisting capacity (WRC), solubility and emulsifying properties of pea isolate samples were determined. It was found that treatment with NPP increased the VUS of pea protein isolates by 1.5 times. The greatest increase was observed in samples treated with a pressure of 400 mPa, at pH=7. An increase in solubility was found with an increase in pH from 6 to 7 when using a pressure of 400 and 600 mPa, however, for a sample of soybean isolate at pH 7 and a pressure of 200 mPa, on the contrary, a decrease in solubility was recorded. It has been shown that the effect of NPP on the emulsifying properties of pea protein depends on the processing conditions. In some cases, HPP can improve emulsifying properties, providing more stable emulsions. However, increasing exposure to high pressure up to 600 mPa leads to a decrease in emulsifying stability. The optimal parameters for using NPP for pea isolate proteins are a pH in the range of 6-7, and a pressure of 400 mPa.","PeriodicalId":516588,"journal":{"name":"New Technologies","volume":null,"pages":null},"PeriodicalIF":0.0,"publicationDate":"2024-01-16","publicationTypes":"Journal Article","fieldsOfStudy":null,"isOpenAccess":false,"openAccessPdf":"","citationCount":null,"resultStr":null,"platform":"Semanticscholar","paperid":"140506287","PeriodicalName":null,"FirstCategoryId":null,"ListUrlMain":null,"RegionNum":0,"RegionCategory":"","ArticlePicture":[],"TitleCN":null,"AbstractTextCN":null,"PMCID":"","EPubDate":null,"PubModel":null,"JCR":null,"JCRName":null,"Score":null,"Total":0}
Pub Date : 2024-01-15DOI: 10.47370/2072-0920-2023-19-4-176-182
Z. N. Khatko, J. M. Begeretova, T. A. Belyavtseva
Due to its unique structure, chemical composition, physical and mechanical properties, grapes are one of the most valuable types of plant raw materials, the processing of which produces by-products: grape pomace, grape seeds, grape bunches, yeast sediments. The amount of grape pomace is about 20-25% of the total mass; if not used, this leads to an increase in production costs. Traditionally, grape pomace has been used as fertilizer or animal feed, but only the polyphenol content has been studied. Grape pomace is a complex natural composition of various components: skins, stems, grape seeds (seeds). Red wine marc is a by-product of fermentation, while white and rosé wine marc is removed before alcoholic fermentation, leaving the fermentable sugars in the marc. They contain organic acids, vitamins, microelements, and grape oil extracted from the seeds. The industry is expected to function as a natural ecosystem, with waste from one industry becoming the raw material for another. In order to rationally use natural raw materials, the main emphasis is on the development and implementation of new competitive high-tech safe technologies, as well as the search for new sources of biologically active substances from waste from food enterprises. The purpose of the research is to study the quality indicators of grape marc obtained using the white and red methods of processing grapes as raw materials for the production of functional soft drinks. It has been established that grape pomace is represented mainly by skins (84.8-87%). The main acids in grape pomace are tartaric («Firstborn of Magarach», «Cabernet Sauvignon») and malic. The main cation is potassium («Rkatsiteli»). The rich chemical composition provides enormous potential for the use of secondary grape processing products for the production of functional soft drinks.
{"title":"Investigation of quality indicators of grape pomace of white and red grape varieties as pectin-containing raw materials used in the design of functional soft drinks","authors":"Z. N. Khatko, J. M. Begeretova, T. A. Belyavtseva","doi":"10.47370/2072-0920-2023-19-4-176-182","DOIUrl":"https://doi.org/10.47370/2072-0920-2023-19-4-176-182","url":null,"abstract":"Due to its unique structure, chemical composition, physical and mechanical properties, grapes are one of the most valuable types of plant raw materials, the processing of which produces by-products: grape pomace, grape seeds, grape bunches, yeast sediments. The amount of grape pomace is about 20-25% of the total mass; if not used, this leads to an increase in production costs. Traditionally, grape pomace has been used as fertilizer or animal feed, but only the polyphenol content has been studied. Grape pomace is a complex natural composition of various components: skins, stems, grape seeds (seeds). Red wine marc is a by-product of fermentation, while white and rosé wine marc is removed before alcoholic fermentation, leaving the fermentable sugars in the marc. They contain organic acids, vitamins, microelements, and grape oil extracted from the seeds. The industry is expected to function as a natural ecosystem, with waste from one industry becoming the raw material for another. In order to rationally use natural raw materials, the main emphasis is on the development and implementation of new competitive high-tech safe technologies, as well as the search for new sources of biologically active substances from waste from food enterprises. The purpose of the research is to study the quality indicators of grape marc obtained using the white and red methods of processing grapes as raw materials for the production of functional soft drinks. It has been established that grape pomace is represented mainly by skins (84.8-87%). The main acids in grape pomace are tartaric («Firstborn of Magarach», «Cabernet Sauvignon») and malic. The main cation is potassium («Rkatsiteli»). The rich chemical composition provides enormous potential for the use of secondary grape processing products for the production of functional soft drinks.","PeriodicalId":516588,"journal":{"name":"New Technologies","volume":null,"pages":null},"PeriodicalIF":0.0,"publicationDate":"2024-01-15","publicationTypes":"Journal Article","fieldsOfStudy":null,"isOpenAccess":false,"openAccessPdf":"","citationCount":null,"resultStr":null,"platform":"Semanticscholar","paperid":"140508789","PeriodicalName":null,"FirstCategoryId":null,"ListUrlMain":null,"RegionNum":0,"RegionCategory":"","ArticlePicture":[],"TitleCN":null,"AbstractTextCN":null,"PMCID":"","EPubDate":null,"PubModel":null,"JCR":null,"JCRName":null,"Score":null,"Total":0}
Pub Date : 2024-01-15DOI: 10.47370/2072-0920-2023-19-4-168-175
A. V. Fedorov, A. Khlopov, E. Lybenko
Modern Russians do not receive enough polyunsaturated fatty acids in their diet, as well as more than half the recommended dietary fiber intake. One of the sources of enriching the human diet with these nutrients can be flaxseed flour. The reason for the rare use of flaxseed flour in baking is the change in the taste and aroma of the finished product. Research to determine the method of adding flaxseed flour was carried out in the laboratory of baking and confectionery production of Vyatka State Technical University. Flax flour was added to bread in the form of sourdough mixed with rye flour, dough from flax flour, and dough from a mixture of flax and rye flour, as well as in dry form into the dough. Organoleptic and physico-chemical quality indicators of semi-finished and finished products were studied. Generally accepted research methods were used in the research. As a result, it has been found that flaxseed flour changes the taste and smell of rye bread to the least extent when it is fermented with yeast in a dough. Fermenting flaxseed flour together with rye flour does not result in the loss of flaxseed taste and aroma. It has been proved that preparing dough using flaxseed flour requires more water than preparing sourdough and dough from rye flour. Sourdough with the addition of flaxseed flour gains acidity faster. Bread with the addition of flaxseed flour in the form of dough is practically no different from the control variant. The crumb of such bread has an acidity of 9.0 degrees, moisture content of 49.9% and porosity of 49%. The tasting has shown that bread with the addition of flax dough among the studied samples scored the highest number of points and was as close as possible to the control version.
{"title":"The influence of methods of adding flaxseed flour on the quality indicators of rye bread","authors":"A. V. Fedorov, A. Khlopov, E. Lybenko","doi":"10.47370/2072-0920-2023-19-4-168-175","DOIUrl":"https://doi.org/10.47370/2072-0920-2023-19-4-168-175","url":null,"abstract":"Modern Russians do not receive enough polyunsaturated fatty acids in their diet, as well as more than half the recommended dietary fiber intake. One of the sources of enriching the human diet with these nutrients can be flaxseed flour. The reason for the rare use of flaxseed flour in baking is the change in the taste and aroma of the finished product. Research to determine the method of adding flaxseed flour was carried out in the laboratory of baking and confectionery production of Vyatka State Technical University. Flax flour was added to bread in the form of sourdough mixed with rye flour, dough from flax flour, and dough from a mixture of flax and rye flour, as well as in dry form into the dough. Organoleptic and physico-chemical quality indicators of semi-finished and finished products were studied. Generally accepted research methods were used in the research. As a result, it has been found that flaxseed flour changes the taste and smell of rye bread to the least extent when it is fermented with yeast in a dough. Fermenting flaxseed flour together with rye flour does not result in the loss of flaxseed taste and aroma. It has been proved that preparing dough using flaxseed flour requires more water than preparing sourdough and dough from rye flour. Sourdough with the addition of flaxseed flour gains acidity faster. Bread with the addition of flaxseed flour in the form of dough is practically no different from the control variant. The crumb of such bread has an acidity of 9.0 degrees, moisture content of 49.9% and porosity of 49%. The tasting has shown that bread with the addition of flax dough among the studied samples scored the highest number of points and was as close as possible to the control version.","PeriodicalId":516588,"journal":{"name":"New Technologies","volume":null,"pages":null},"PeriodicalIF":0.0,"publicationDate":"2024-01-15","publicationTypes":"Journal Article","fieldsOfStudy":null,"isOpenAccess":false,"openAccessPdf":"","citationCount":null,"resultStr":null,"platform":"Semanticscholar","paperid":"140507586","PeriodicalName":null,"FirstCategoryId":null,"ListUrlMain":null,"RegionNum":0,"RegionCategory":"","ArticlePicture":[],"TitleCN":null,"AbstractTextCN":null,"PMCID":"","EPubDate":null,"PubModel":null,"JCR":null,"JCRName":null,"Score":null,"Total":0}
Pub Date : 2024-01-15DOI: 10.47370/2072-0920-2023-19-4-48-55
A. Vasyukova, A. Moshkin, I. Bogonosova
The purpose of the research is to evaluate flavor compositions formed during the action of high temperatures on individual processes of the technological scheme for the production of vegetable semi-finished products and complex interaction in the structure of the finished product, taking into account the use of carbohydrate-protein fillers. The research presents some features of the flow of physicochemical reactions that make it possible to describe the dynamics of the interaction of nutrients in the formed binary compositions of carbohydrate-fat structures of plant systems in the process of temperature exposure. The methods used. To carry out the tests, the potentiometric method was used and the pH of each sample was determined using the Expert-001-3pH device. Determinations of sugars were carried out according to GOST 8756.13-87 using the permanganate method; dry substances according to GOST 31640-2012; organoleptic assessment according to GOST ISO 6658–2015. The objects: samples of semi-finished products containing 12, 24, 36% carrots and 4, 8, 12% onions. The results. It has been established that sauteing treatment promotes the formation of a complex of flavoring and aromatic substances, depending on the type of vegetables. With increasing intensity of processing, the concentration of carbohydrates in the sautes increases, as well as the amount of dry matter. It has been found that in all samples the amount of organic acids increases with increasing temperature, pH decreases in carrots from 6.0-6.3; 5.5-7.0 to 4.2-5.9, and onions from 5.5-6.1; 6.4-7.9 to 3.0-5.0. For clarity of experiments, graphs of the dependence of the processing intensity on the amount of dry substances, carbohydrates, tissue softening and the formation of the flavor and aromatic range have been presented. Conclusion. The experimental data and dependencies obtained will be useful when considering more complex processes of mass transfer, sucrose inversion, and destruction of protein-carotenoid complexes. The perception of raw carrots is complex: the balance between sweetness and bitterness, which are the main criteria for the sensory quality of carrots. It intensifies when sauteed. A richer sweet taste appears. This perception of sweetness is determined by the ratio: sugar and bitterness. It does not have a direct correlation with the total sugar content in samples with carrots and sautéed onions.
{"title":"Formation of flavor compositions of vegetable casseroles using carbohydrate-fat fillers","authors":"A. Vasyukova, A. Moshkin, I. Bogonosova","doi":"10.47370/2072-0920-2023-19-4-48-55","DOIUrl":"https://doi.org/10.47370/2072-0920-2023-19-4-48-55","url":null,"abstract":"The purpose of the research is to evaluate flavor compositions formed during the action of high temperatures on individual processes of the technological scheme for the production of vegetable semi-finished products and complex interaction in the structure of the finished product, taking into account the use of carbohydrate-protein fillers. The research presents some features of the flow of physicochemical reactions that make it possible to describe the dynamics of the interaction of nutrients in the formed binary compositions of carbohydrate-fat structures of plant systems in the process of temperature exposure. The methods used. To carry out the tests, the potentiometric method was used and the pH of each sample was determined using the Expert-001-3pH device. Determinations of sugars were carried out according to GOST 8756.13-87 using the permanganate method; dry substances according to GOST 31640-2012; organoleptic assessment according to GOST ISO 6658–2015. The objects: samples of semi-finished products containing 12, 24, 36% carrots and 4, 8, 12% onions. The results. It has been established that sauteing treatment promotes the formation of a complex of flavoring and aromatic substances, depending on the type of vegetables. With increasing intensity of processing, the concentration of carbohydrates in the sautes increases, as well as the amount of dry matter. It has been found that in all samples the amount of organic acids increases with increasing temperature, pH decreases in carrots from 6.0-6.3; 5.5-7.0 to 4.2-5.9, and onions from 5.5-6.1; 6.4-7.9 to 3.0-5.0. For clarity of experiments, graphs of the dependence of the processing intensity on the amount of dry substances, carbohydrates, tissue softening and the formation of the flavor and aromatic range have been presented. Conclusion. The experimental data and dependencies obtained will be useful when considering more complex processes of mass transfer, sucrose inversion, and destruction of protein-carotenoid complexes. The perception of raw carrots is complex: the balance between sweetness and bitterness, which are the main criteria for the sensory quality of carrots. It intensifies when sauteed. A richer sweet taste appears. This perception of sweetness is determined by the ratio: sugar and bitterness. It does not have a direct correlation with the total sugar content in samples with carrots and sautéed onions.","PeriodicalId":516588,"journal":{"name":"New Technologies","volume":null,"pages":null},"PeriodicalIF":0.0,"publicationDate":"2024-01-15","publicationTypes":"Journal Article","fieldsOfStudy":null,"isOpenAccess":false,"openAccessPdf":"","citationCount":null,"resultStr":null,"platform":"Semanticscholar","paperid":"140507802","PeriodicalName":null,"FirstCategoryId":null,"ListUrlMain":null,"RegionNum":0,"RegionCategory":"","ArticlePicture":[],"TitleCN":null,"AbstractTextCN":null,"PMCID":"","EPubDate":null,"PubModel":null,"JCR":null,"JCRName":null,"Score":null,"Total":0}
Pub Date : 2024-01-15DOI: 10.47370/2072-0920-2023-19-4-97-102
N. Kachaeva, N. N. Maleev, Kh. E. Kachaev
Liquor products are represented by a wide range of drinks. Despite this diversity, they are all united by the use of semi-finished products (alcoholic juices, pestilences and infusions) during blending. Extraction of components of plant raw materials is one of the key processes for obtaining semi-finished alcoholic beverages. The quality indicators of the finished liquor product directly depend on their composition and quality. The purpose of the research is to study the vibration effect as a physical method of intensifying the process of extracting flavoring and aromatic compounds of fruit and berry raw materials when obtaining semi-finished products for distillery production (infusions and juices). To study the effect of vibration exposure on the content of substances responsible for taste, such technical factors as frequency (f), amplitude (A) and duration (τ) of exposure have been taken into account. The mass concentration of phenolic and coloring substances has been taken as controlled indicators. The processing was carried out on the installation developed at the Department of Winemaking and Fermentation Technology named after Professor A.A. Merzhanyan of FSBEI HE «KubSTU». The research was conducted on semi-finished products obtained from raspberries and cherries in the process of obtaining alcoholized components of a blend of liqueurs. In this case, the ratio of components was equal to 1:1. A comparison of the indicators was carried out with a sample obtained by stationary infusion. The positive influence of vibration during the extraction process with aqueous-alcohol solutions on the quality indicators of semi-finished products was established. Optimal processing parameters were also determined to reduce the duration of the process. The data obtained allow us to judge the feasibility of using vibration in the alcoholic beverage industry as a technique that accelerates infusion and improves the quality of semi-finished products.
{"title":"Studying the influence of vibration on the process of obtaining semi-finished products for distillery production","authors":"N. Kachaeva, N. N. Maleev, Kh. E. Kachaev","doi":"10.47370/2072-0920-2023-19-4-97-102","DOIUrl":"https://doi.org/10.47370/2072-0920-2023-19-4-97-102","url":null,"abstract":"Liquor products are represented by a wide range of drinks. Despite this diversity, they are all united by the use of semi-finished products (alcoholic juices, pestilences and infusions) during blending. Extraction of components of plant raw materials is one of the key processes for obtaining semi-finished alcoholic beverages. The quality indicators of the finished liquor product directly depend on their composition and quality. The purpose of the research is to study the vibration effect as a physical method of intensifying the process of extracting flavoring and aromatic compounds of fruit and berry raw materials when obtaining semi-finished products for distillery production (infusions and juices). To study the effect of vibration exposure on the content of substances responsible for taste, such technical factors as frequency (f), amplitude (A) and duration (τ) of exposure have been taken into account. The mass concentration of phenolic and coloring substances has been taken as controlled indicators. The processing was carried out on the installation developed at the Department of Winemaking and Fermentation Technology named after Professor A.A. Merzhanyan of FSBEI HE «KubSTU». The research was conducted on semi-finished products obtained from raspberries and cherries in the process of obtaining alcoholized components of a blend of liqueurs. In this case, the ratio of components was equal to 1:1. A comparison of the indicators was carried out with a sample obtained by stationary infusion. The positive influence of vibration during the extraction process with aqueous-alcohol solutions on the quality indicators of semi-finished products was established. Optimal processing parameters were also determined to reduce the duration of the process. The data obtained allow us to judge the feasibility of using vibration in the alcoholic beverage industry as a technique that accelerates infusion and improves the quality of semi-finished products.","PeriodicalId":516588,"journal":{"name":"New Technologies","volume":null,"pages":null},"PeriodicalIF":0.0,"publicationDate":"2024-01-15","publicationTypes":"Journal Article","fieldsOfStudy":null,"isOpenAccess":false,"openAccessPdf":"","citationCount":null,"resultStr":null,"platform":"Semanticscholar","paperid":"140508132","PeriodicalName":null,"FirstCategoryId":null,"ListUrlMain":null,"RegionNum":0,"RegionCategory":"","ArticlePicture":[],"TitleCN":null,"AbstractTextCN":null,"PMCID":"","EPubDate":null,"PubModel":null,"JCR":null,"JCRName":null,"Score":null,"Total":0}
Pub Date : 2024-01-15DOI: 10.47370/2072-0920-2023-19-4-80-90
R. A. Zhuravlev, E. Barashkina, T. A. Dzhum, M. Y. Tamova
The article investigates the development of functional confectionery products. It seems relevant to use non-traditional recipe components with increased nutritional value. As a basis for the design of such food products, pastille products containing technologically necessary and useful functional components – protein and pectin – are proposed. A promising source for replacing sugar is fructose-glucose syrup. The object of the research is pastille products with increased nutritional value using non-traditional recipe components. Quince was used as a fruit filling for marshmallows. Expanding the range of plant raw materials used in the production of pastille products, it is advisable to use legumes, which supposedly have a high foaming ability due to the presence of a complex of surfactants in their composition. Legumes are characterized by high nutritional value, have a wide distribution area and are included in the diet of the majority of the Russian population. The purpose of the research is to develop a confectionery sugary product with a whipped structure – marshmallows of increased nutritional value using processed legume products – aquafaba, as well as fructose-glucose syrup. In the course of experimental studies conducted at the Department of Public Nutrition and Service of the Kuban State Technical University, the authors substantiated the choice of non-traditional raw materials to be included in the recipe composition and technology for the production of marshmallows with increased nutritional value. Research has been carried out and the process of foaming and foam resistance of dispersed systems based on aquafaba of canned chickpeas has been optimized. The technology and the recipe for marshmallows with increased nutritional density have been developed based on quince puree, aquafaba, canned chickpeas and fructose-glucose syrup. The main consumer properties of the finished product have been studied: organoleptic characteristics, chemical composition, nutritional value, hygienic safety indicators. The conclusions: in the development of confectionery products, an increase in their nutritional value, a reduction in calorie content, and the replacement of sucrose with sweeteners of natural origin have been achieved, which makes it possible to recommend them for inclusion in the diet of people suffering from diabetes.
{"title":"The use of non-traditional prescription components to expand the range of functional pastille products","authors":"R. A. Zhuravlev, E. Barashkina, T. A. Dzhum, M. Y. Tamova","doi":"10.47370/2072-0920-2023-19-4-80-90","DOIUrl":"https://doi.org/10.47370/2072-0920-2023-19-4-80-90","url":null,"abstract":"The article investigates the development of functional confectionery products. It seems relevant to use non-traditional recipe components with increased nutritional value. As a basis for the design of such food products, pastille products containing technologically necessary and useful functional components – protein and pectin – are proposed. A promising source for replacing sugar is fructose-glucose syrup. The object of the research is pastille products with increased nutritional value using non-traditional recipe components. Quince was used as a fruit filling for marshmallows. Expanding the range of plant raw materials used in the production of pastille products, it is advisable to use legumes, which supposedly have a high foaming ability due to the presence of a complex of surfactants in their composition. Legumes are characterized by high nutritional value, have a wide distribution area and are included in the diet of the majority of the Russian population. The purpose of the research is to develop a confectionery sugary product with a whipped structure – marshmallows of increased nutritional value using processed legume products – aquafaba, as well as fructose-glucose syrup. In the course of experimental studies conducted at the Department of Public Nutrition and Service of the Kuban State Technical University, the authors substantiated the choice of non-traditional raw materials to be included in the recipe composition and technology for the production of marshmallows with increased nutritional value. Research has been carried out and the process of foaming and foam resistance of dispersed systems based on aquafaba of canned chickpeas has been optimized. The technology and the recipe for marshmallows with increased nutritional density have been developed based on quince puree, aquafaba, canned chickpeas and fructose-glucose syrup. The main consumer properties of the finished product have been studied: organoleptic characteristics, chemical composition, nutritional value, hygienic safety indicators. The conclusions: in the development of confectionery products, an increase in their nutritional value, a reduction in calorie content, and the replacement of sucrose with sweeteners of natural origin have been achieved, which makes it possible to recommend them for inclusion in the diet of people suffering from diabetes.","PeriodicalId":516588,"journal":{"name":"New Technologies","volume":null,"pages":null},"PeriodicalIF":0.0,"publicationDate":"2024-01-15","publicationTypes":"Journal Article","fieldsOfStudy":null,"isOpenAccess":false,"openAccessPdf":"","citationCount":null,"resultStr":null,"platform":"Semanticscholar","paperid":"140507691","PeriodicalName":null,"FirstCategoryId":null,"ListUrlMain":null,"RegionNum":0,"RegionCategory":"","ArticlePicture":[],"TitleCN":null,"AbstractTextCN":null,"PMCID":"","EPubDate":null,"PubModel":null,"JCR":null,"JCRName":null,"Score":null,"Total":0}
Pub Date : 2024-01-15DOI: 10.47370/2072-0920-2023-19-4-150-156
N. S. Sanzharovskaya, N. V. Sokol
The production of grain bread is of great practical importance for providing consumers with quality food products. Whole grain bread is a source of carbohydrates, protein, vitamins and minerals necessary for a healthy diet. This study examines the optimization of the production technology of grain bread using electrically activated water. Electroactivated water is an effective tool that allows you to regulate the quality of the finished product. In this regard, the goal of the research was to optimize the technology for the production of grain bread using electrically activated water, assessing its quality characteristics and safety indicators during storage. The objects of the study were wheat grain of the «Tabor» variety; fractions of electroactivated water (anolyte and catholyte); semi-finished products; ready-made grain bread samples. On the basis of a comprehensive assessment a sample of bread was selected, made from dispersed grain based on a dough made from a composite mixture with preliminary soaking of the grain in electrically activated water (anolyte). A technological scheme for the production of grain bread was developed. It has been established that the use of electrically activated water helps to reduce crumbling during storage.
{"title":"Optimization of grain bread production technology using electrically activated water","authors":"N. S. Sanzharovskaya, N. V. Sokol","doi":"10.47370/2072-0920-2023-19-4-150-156","DOIUrl":"https://doi.org/10.47370/2072-0920-2023-19-4-150-156","url":null,"abstract":"The production of grain bread is of great practical importance for providing consumers with quality food products. Whole grain bread is a source of carbohydrates, protein, vitamins and minerals necessary for a healthy diet. This study examines the optimization of the production technology of grain bread using electrically activated water. Electroactivated water is an effective tool that allows you to regulate the quality of the finished product. In this regard, the goal of the research was to optimize the technology for the production of grain bread using electrically activated water, assessing its quality characteristics and safety indicators during storage. The objects of the study were wheat grain of the «Tabor» variety; fractions of electroactivated water (anolyte and catholyte); semi-finished products; ready-made grain bread samples. On the basis of a comprehensive assessment a sample of bread was selected, made from dispersed grain based on a dough made from a composite mixture with preliminary soaking of the grain in electrically activated water (anolyte). A technological scheme for the production of grain bread was developed. It has been established that the use of electrically activated water helps to reduce crumbling during storage.","PeriodicalId":516588,"journal":{"name":"New Technologies","volume":null,"pages":null},"PeriodicalIF":0.0,"publicationDate":"2024-01-15","publicationTypes":"Journal Article","fieldsOfStudy":null,"isOpenAccess":false,"openAccessPdf":"","citationCount":null,"resultStr":null,"platform":"Semanticscholar","paperid":"139640453","PeriodicalName":null,"FirstCategoryId":null,"ListUrlMain":null,"RegionNum":0,"RegionCategory":"","ArticlePicture":[],"TitleCN":null,"AbstractTextCN":null,"PMCID":"","EPubDate":null,"PubModel":null,"JCR":null,"JCRName":null,"Score":null,"Total":0}
京公网安备 11010802042870号
京ICP备2023020795号-1
扫码关注我们
求助内容：
应助结果提醒方式：